| |
| |
|
Hardware Information |
|
|
|
Ceramic Disc Capacitor-How to Accurately Test It
The last article I mentioned about electrolytic capacitor breakdown when under load. In this article I will talk about the high voltage resin coated ceramic disc capacitor. In computer monitor, it is frequent used in the screen voltage (G2) line at the crt board. When it fails, it can cause erratic or intermittently raster bright and dim and sometimes no display. Adjusting the flyback transformer screen control will not solve this problem. You can isolate the problem as whether if it cause by a defective fly back or G2 line at crt board. Remove the G2 wire from circuit and measure the screen voltage with a digital multimeter- it should have a constant voltage (will not vary). If the voltage is not stable suspect the fly back. If it ok then trace the screen voltage circuit. Usually this circuit consist of only resistors and capacitors. Sometimes a defective crt socket might cause this type of problem also! Many times a tech can't solve this intermittent or no display problem is because their digital capacitance and ohmmeter measured ok on the capacitors. The capacitors in the screen voltage line are usually rated of 102,103, and 472 1kv to 2kv. A 'missed' in checking this capacitors will caused the technician can't solve the problem, unless he direct replace the capacitor. An intermittent capacitor can pull down the screen voltage causing the display problem. As mentioned earlier, an ohmmeter with 12v output and a digital capacitance with 3v output are unable to accurately check the capacitor that have the rating of 1-2 kilovolt! If you have the analog insulation tester or meter, the panel will show a short circuit when certain voltage are pump in to check the high voltage capacitor. The voltages that you can select is depends on the brand or model you buy. Some have the range of 50v to 1000v and some have the range from 100v to 500v. It is optional whether you should have one. If you have one then it would be an added advantage for you. The other option that you have is to direct replace the suspected capacitor. In my country, you can get a new one in less than US150.00 or you may bid a used unit from eBay. As for me, checking the small blue resin coated ceramic disc capacitor that have the capacitor code of 104 50v, besides using digital capacitance meter to check for the value, i also use an analog meter set to times 10Kohm that have the output of 12v to check this type of capacitor. Many times it will revealed the bad intermittent capacitor. You will be shocked to see the capacitance meter checked ok but show a shorted reading when check with analog multimeter. In the market there is certain brand of analog multimeter that have the range of 100kohm. If you open up the cover, you can't see the 9v battery in it, what you see only the 2 pieces of 1.5v battery. This type of meter can't accurately detect the short in the capacitor because the output voltage is only 3volt! For those of you who involved in repairing monitor, you will agree with me that checking the flyback internal capacitance- quite often you get the right value 2.7nf with digital capacitance meter but when you switch on the monitor, you will hear a 'tick-tick' sound from the flyback. This is because the capacitor is breaking down when under load. If you did not do anything with the flyback, gradually the internal capacitance will become shorted and you will need to refurbish the flyback. Jestine Yong is a electronic repairer and a writer. For more electronic repair information please visit his website at http://www.noahtec.com/electronic-repair-articles.htm
MORE RESOURCES:
hardware - Google News |
|
|
|
RELATED ARTICLES
The Road Ahead We live in an area that has begun to use GreenBins for household waste. Our regular garbageispicked up every other week and the onlyweekly garbage collection is our green plasticbins, to be filled with leftover food productsand other organic waste. Drop On Demand Printers Most HP and Epson printers are drop on demand printers. They use electrical pulses to fulfill requests for ink. The Top 10 Must-Have Laptop Accessories You've laid out good money for your laptop computer, but you're not done spending just yet.There are a few more laptop accessories you may want to consider to make the package complete. Selecting a Laptop Small Can Be BeautifulWhen purchasing a new computer, you may be better served by a laptop than a traditional desktop computer. Recently, laptops with capabilities similar to desktops can be purchased for a comparable price. Inkjet Printer Tips to Select Proper Printer If you are tight on budget, go for Inkjet Printer. Inkjet Printers are more economical compared to Laser Printers. Easy to Execute! Plug and play equipment or hardware solves the problem of driver installation, re-starting routines, and generally speaking, "hassle", for those who are not technically proficient.If your computer supports "Plug and Play", then, as the name suggests, you simply plug it in and play. Understanding Transistor Data and Replacement If, for some reason, you can't get an exact replacement for the transistor that you want to replace, you can refer to one of the transistor substitution guides or book, and try to identify a "near replacement". Beware, however. How to Change, Upgade or Remove an IDE Hard Drive Hard drives - Hard drives are a little more complicated. First off, you have to know what you want to do with the hard drive. A Review of Refurbished HP Laptops HP refurbished laptops can be found on their website hpshopping.com. What is Over-clocking a Processor? Q : What is over clocking?Overclocking is when you make your system processor run faster that its normal speed. This has many advantages and dis-advantages. Dusting Your Computer - Keeping it Cool My mother always told me to dust, but I never did, mostly because I was lazy, but also because I couldn't find any tangible benefit to dusting. I just didn't see how I'd benefit from my room or my things being less dusty. Whats In An LCD Display? Who needs an LCD display? Well, if you're like me, having one huge hunk of a monitor sitting on your desktop is just not feasible. Not only does it take up desk space, but there's just simply no need for all of the physical mass, right?Welcome LCD displays-the computer monitors of the present and future. Wireless Networking, Part 2: Setup and Security The first installment in this two-part series of Tech Tips provided an introduction to the basic capabilities and hardware involved in wireless networking. In the final installment of this two-part series, we will look at some of the basic setup and security considerations that should be addressed. Expansion Cards Part 1: (of a 3 part series) PCIThe expansion slots available on motherboards allow for a variety of upgrades in a computer system, but matching the appropriate card to an available slot needs to be addressed before making any purchasing decisions. The most common types of expansion cards for modern computer systems can be broken down into three formats: PCI, AGP, and PCI Express. Learn How To Diagnose Power Supply Problems The Power Supply convert's your regular household current into low DC voltage used by the computer. When this component fails,there is simply no activity going on wih your computer. Laptop and Notebook Theft Prevention Laptops or Notebook computers are an expensive personal and business asset that are highly sought after by both small time thieves and large complicated theft rings. Keeping your laptop and notebook computers safely in your possession should always be in the back of your mind. Ink Cartridges - A Humble Beginning Computers and their accompanying printers were huge years ago. In the past toner reservoirs and toner cartridges were used instead of ink cartridges like those used now. ABCs Of DVD Drive Abbreviations The number of different formats available in DVD drives can be confusing to anyone in the market for one. The list is much longer, but to address a few of the common formats, we have DVD-ROM, DVD-R, DVD-RW, DVD+R, DVD+RW, DVD-RAM ,DVD+R DL and DVDRW. Top Three Factors to Consider While Choosing a Data Center for Your Business Data Centers are the core of the Internet. The computer servers that power the Interne,t call Data Centers their home. What Is A Fuse? And How To Test It. A fuse is a very thin wire, which either melts or vaporizes when too much current flows through it. The thin wire may be made of aluminum, tin-coated copper or nickel.
|
| Article List | Index | Site Map |
|
All logos, trademarks and articles on this site are property and copyright of their respective owner(s).
The comments are property of their posters, all the rest is Copyright © 2006 CanadaSEEK.com - All Rights Reserved. |
